Product ID:PLIOBOND 20
MSDS Date:01/01/1987
FSC:8040
NIIN:00-200-4574
MSDS Number: BDJGQ

W J RUSOCE CO(RAGEN DATA SYSTEMS)

485 KENMORE BLVD
AKRON, OH 44314
US

Emergency Phone: NONE

Cage: KO580

W J RUSOCE CO(RAGEN DATA SYSTEMS)

3858 AKRON, OH 44314 US

Telephone: 216-253-8148

Cage: KO580

SYNTHETIC RUBBER CAS# N/R

Fraction By Weight: 5-10%

CALCIUM CARBONATE (MARBLE) (LIMESTONE)

CAS: 1317-65-3

RTECS: EV9580000

Fraction By Weight: 1-5%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9192

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Effects of Overexposure:EYE:IRRIT,RED,TEAR,BLUR.INHAL:NASAL,RESP
IRRIT,DIZ,WEAK,NAUS,HDCH,UNCON,ASPHYXIATION.OTH PRECAUTION

First Aid:SKIN:WASH W/ SOAP,WATER.REMOVE CONTAM CLOTH.WASH CONTAM CLOTH
BEFORE REUSE.EYE:FLUSH W/ WATER. CALL MD.INGET:IMMED DRINK 2 GLASS
OF WATER,INDUCE VOMIT.CALL MD IMMED.INHAL:REMOVE TO FRESH AIR GIVE
O*2, CPR.KEEP WARM,QUIET,GET MEDICAL ATTENTION.

Flash Point:23F,-5C TOC
Lower Limits:2.0
Extinguishing Media:REGULAR FOAM,CO*2,CR DRY CHEMICAL.
Fire Fighting Procedures:WEAR SCBA W/ FULL FACEPIECE,FULL BODY
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAP MAY TRAVEL ALONG GROUND,BE MOVE BY
VENT,IGNIT BY IGNIT SOURCES.NEVER WELD,CUT NEAR DRUM.SUPP

Spill Release Procedures:ELIMINATE ALL IGNIT SOURCES.SM SPILL:ABSORB
LIQ ON PAPER,VERMICULITE,FLOOR ABSORBENT,TRANS TO HOOD.LRG
SPILL:WEAR PROT EQUIP,DIKE SPILL,PUMP LIQ TO SALVAGE TANK.REMAINING
LIQ MAY BE TAKEN UP ON ABSORB ENT MATERIAL,SHOVELED INTO
CONTAINERS.

Handling and Storage Precautions:CONTAINERS OF THIS MATRL MAY BE HAZ
WHEN EMPTIED.SINCE EMPTIED CONTAIN RETAIN PROD RESIDUE,ALL HAZ
PRECAUT GIVEN IN THIS HMIS RECORD MUST BE OBSERVED.
Other Precautions:N/K.OVEREXPOS:INGEST:GI IRRIT,NAUS,VOMIT,DIARR.

Respiratory Protection:NIOSH/MSHA APPRVD AIR SUPPLIED RESP IF TLV IS
EXCEEDED.
Ventilation:MECH(GENERAL,LOCAL EXHAUST)TO KEEP BELOW TLV.
Protective Gloves:NEOPRENE
Eye Protection:CHEM SPLASH GOGGLES
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING,BOOTS.
Supplemental Safety and Health
MSDS PREP:01MAR86.SPEC FIRE.EXPLOS:5 GL PAIL OR LARGER SHOULD BE
GROUNDED,BONDED WHEN MATRL IS TRANSFERRED.%VOLATILE:76-80.CALL MFR
FOR SOLUBILITY,APPEARANCE.

HCC:F2
Boiling Pt:B.P. Text:176F,80C
Vapor Pres:71
Vapor Density:2.5
Spec Gravity:0.860
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:TAN LIQUID,GARLIC,KETONE ODOR.
Percent Volatiles by Volume:SUPP

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY FORM TOXIC
MATRL,CO*2,CO,HYDROCARBONS,N COMP,HCN.

Waste Disposal Methods:DISPOSE IN ACCORDANCE W/ LOCAL,STATE,FEDERAL
REGULATIONS.SM SPILL:EVAP IN HOOD.DISPOSE OF REMAIN MATRL IN ACCORD
W/ APPLICABLE REG.LRG SPILL;INCINERATION.CONTAMINATED ABSORBENT MAY
BE DEPOSITED IN A L ANDFILL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.